Lightweight Lithium Ion starter battery, 1.98 lb / 900 gram, specially developed for motorcycles, jet-skis, snowmobiles, ATVs and Quads.
- up to 1000cc 4 stroke
- up to 300cc 2 stroke
- Yamaha, Honda, Suzuki, BMW, Super Bike 1000cc, all models
- Yamaha, Honda, Suzuki, Super sport 600cc, all models
- All 450 ATV's
- All 450 Dirt bikes
- All 450 Enduro bikes
- KTM 300 EXC 2 stroke, all models
- Microlight Flying / Ultralight aviation
This newly developed battery is designed to replace the much heavier 10 to 12 Ah lead/acid battery.
The super B 5200 is based on the safe Lithium Iron Phosphate technology (LiFePO4), better known as Lithium Ion.
The super B 5200 delivers up to 300 Cranking Amps.
The super B 5200 offers many advantages over conventional 10 to 12 Ah lead/acid batteries:
- weighs less: as much as 80% weight saving; 1.98 lb / 900 grams;
- recharges many times faster: within 5 minutes after starting your engine the battery will be recharged;
- is much smaller: 1/3 or less of the space; 4.49 inch, 3.2 inch, 2.4 inch (WxHxD) / 114mm x 81.25mm x 62mm (WxHxD);
- has a longer service life: more than 5 years instead of 2 to 3 years;
- has a low self-discharge rate.
super B batteries are based on Lithium Iron Phosphate technology (LiFePO4). This so called Lithium Ion technology as used in the super B batteries is the safest Lithium Ion technology today. On top of that our specially designed casing and electronics further increase safety and durability.
super B 5200 refers to 5.2 Ah (Amps/Hour), which represents the real nominal capacity under maximum continuous load. How different this is from lead / acid batteries where manufactures provide a 20 hour rating. For example the 10 Ah lead / acid batterie can be discharged over a period of 20 hours with a 0.5 Amp load. This is not very practical, as the same 10 Ah battery discharged with a 2,5 Amp load, for example a 25 Watt light bulb, will yield no more than 2.2 Ah of energy. The lead-acid battery, therefore, has less capacity when the load increases, which means that you can start more often with the super B.
We use a 10-second rating instead of CCA for the super B 5200 battery. The 10-second rating is easy to understand: it represents the amount of current a battery can produce during 10 seconds without being damaged. The super B 5200 can deliver a current of 300 Amps during 10 seconds. The batteries can deliver higher currents for shorter periods and lower currents for longer periods.
The super B 5200 battery can be charged with almost all motorbikes, up to a maximum of 14.4 Volts. Do not overcharge, as this will damage the battery. The super B charges much faster than conventional batteries: charging a lead- acid battery takes 7 to 14 hours, during which the internal resistance increases and the charge current decreases. The super B 5200 can be charged within 1 hour at a charge current of 6 Amps. If the charge current is increased to 12 Amps, it will charge in 30 minutes. Do not charge the battery with more than 20 Amps as this will damage the battery.
We recommend to use the appropriate super B charger to charge super B batteries. Do not use a lead-acid charger, as these chargers are optimized for a different battery technology and make use of methods for charging and safeguarding which are unsuitable for super B batteries.
Over 5 years.
Connecting the battery
The super B 5200 battery is designed with M6 screw terminals, this makes it easy to replace the stock lead-acid battery. The super B 5200 battery is shipped with two M6 bolds and plastic end caps to fit to the wires on the bike
As super B batteries have a very low self-discharge rate, the batteries will last for several years in storage.
F.I.M. / Stock Racing
The F.I.M. modified the regulations for stock racing regarding battery use.
Article 22.214.171.124 Battery:
The Battery may be replaced. If replaced, its nominal capacity must be equal to or higher than the Homologated type. The F.I.M. has approved the super B battery for use as replacement battery.
|Nominal capacity and voltage
||5200 mAh, 13.2 V
|EqPb (Equals lead acid battery)
||10 to 12Ah
|Recommended standard charge method
||7A to 14.4 CCCV, 45 min
|Recommended fast charge current
||20A to 14.4 CCCV, 15 min
|Maximum continuous discharge
|Recommended charge and cut-off V at 25°C
||14.4V to 8V
|Recommended charge and cut-off V below 0°C
||15.2V to 2V
|Operating temperature range
||-22°F to +140°F / -30°C to +60°C
|Storage temperature range
||-58°F to +140°F / -50°C to +60°C
||1.98 lb / 900 grams
||4.49 inch, 3.2 inch, 2.4 inch (WxHxD)
||114mm x 81.25mm x 62mm (WxHxD)
2 year limited factory warranty.